OUR PRODUCT RANGE
PERMA FLOOR SEAL
CONCRETE FLOOR DUST PROOFER AND HARDENER
Even the best concreted industrial floors loose their looks because of surface weakness and dusting. A small care such as use of a dust proofer and floor hardener on new floor at a very nominal cost ensures long life and good looks to an industrial floor. Perma Floor Seal is a micro crystalline powder which is diluted with water and applied on the floors to get the desired dust proof and healthy performance of floors.
To make the floor surface hard, durable and dust proof. Suitable for:
- Factory Floors
- Industrial units
- Warehouses and transit sheds
- Generator rooms
- Both new as well as old floors can be treated with Perma Floor Seal.
- Perma Floor Seal makes the surface strong and durable.
- Perma Floor Seal makes the surface dust proof.
- There is no need for surface preparation and curing.
- The floor can be open to traffic even during treatment.
- It improves chemical resistance of the floor.
DIRECTIONS FOR USE
Perma Floor Seal is applied on cleaned concrete floors in three coats with 12 hours intervals between coats.
- Dissolve 1 kg of Perma Floor Seal crystals in 6 litres of water and apply by brush, mop or just flood the surface.
- After 12 hours dissolve 1 kg of Perma Floor Seal Crystals in 3 Litres of water and apply as stated above.
- After 12 hours repeat operation (2) above.
- After 12 hours clean the surface with clean water and put it to use.
Perma Floor Seal crystals when dissolved in water and applied on concrete surface, penetrates deep into the concrete through the capillaries and reacts with calcium oxide in cement to form non soluble crystals. These crystals effectively block the capillaries and effectively fill up all the surface pores making the whole concrete dense. This minimises penetration of chemical spillages etc. into concrete thus making it weak. The pore blocked surface becomes dust free.
1st Coat 250 gms/100 sq. ft. subsequent coats 400 gms/ 100 sq. ft. For three coats 1 kg covers 100 sq.ft.
HEALTH AND SAFETY
Perma Floor Seal produces a strong alkaline solution. Eyes and skin should be protected from splashing. Contact with skin should be washed with plenty of water. If eyes are affected clean with adequate running water and seek medical help. During treatment hand gloves and gum boots are recommended.
Perma Floor Seal is available in 25 kg HDPE sack.
Perma Floor Seal has a shelf life of 24 months if kept in cool and dry conditions.
PERMA warrants that all products are free from any defects of manufacture and comply with the specifications given in their respective technical data sheet. No warranty can be given as to the results of use because conditions of use, such as site conditions, surface preparations, workmanship, weather, structural issues and other factors are beyond the control of PERMA. Purchaser agrees to seek the advice of qualified professionals to carry out tests & take trials to determine the suitability of products for their intended purpose prior to full scale usage of PERMA products and assumes all risks.
The company does not assume any liability for unsatisfactory results, arising from the use of our products. Purchaser’s sole liability is limited to replacement of product or refund of the purchase price paid if any product proven defective. No other warranties, express or implied, shall apply including any warranty of merchantability or fitness for a particular purpose. PERMA shall not be liable for any consequential damages arising from the use of our products for unsatisfactory results.
The information supplied in this datasheet is based on our experience through extensive research and is given in good faith in order to help prospective users. We reserve the right to update the information provided in our technical data sheet at any time without prior notice within the scope of technical progress or new developments.
Click the below Button to print the current page.